Wikipedia

Trolleytruck

For the hand-operated two-wheeled cart, see Hand truck.

A trolleytruck (also known as a freight trolley or trolley truck[1]) is a trolleybus-like vehicle used for carrying cargo instead of passengers. A trolleytruck is usually a type of electric truck powered by two overhead wires, from which it draws electricity using two trolley poles. Two current collectors are required in order to supply and return current, because the return current cannot pass to the ground (as is done by streetcars on rails[2]) since trolleytrucks use tires that are insulators. Lower powered trucks, such as might be seen on the streets of a city, tend to use trolley poles for current collection. Higher powered trucks, such as those used for large construction or mining projects, may exceed the power capacity of trolley poles and have to use pantographs instead.[3][4] Trolleytrucks have been used in various places around the world and are still in use in cities in Russia and Ukraine, as well as at mines in North America and Africa. Because they draw power from the mains, trolleytrucks can use renewable energy sources – modern trolleytrucks systems are under test in Sweden and Germany along highways using diesel–electric hybrids to reduce emissions.

Trolleytruck KTG-1 in Saint Petersburg, Russia

Use throughout the world

edit

Austria

edit

Trolleytrucks were used in St. Lambrecht, Austria, by the Nobel Industries dynamite factory from 16 November 1945 to 21 April 1951.[5] Trolleytrucks were used to carry dynamite over the Alps just after World War II due to the shortages of material that for a time prevented the use of diesel trucks. In the 1950s the material shortages had been alleviated so the trolleytrucks were replaced with diesel trucks and the former power lines were taken down. Some trucks from the abandoned line were reconverted to trolley buses and used along streets in Kapfenberg.[6]

Bulgaria

edit

A Ukrainian built trolleytruck started service in Pleven, Bulgaria, in 1987, but that truck may no longer be in service since it is stored in the trolleybus depot.[7]

Canada

edit

The Québec Cartier Mining Company used trolleytrucks in its iron ore mine in Québec from 1970 until 1977, when the iron ore deposit was exhausted and the mine closed down. The power supply for this remote mine was an 1,800-horsepower (1,340 KW) power plant taken out of a diesel locomotive.[4]

As of 2022 the Copper Mountain Mining Corporation operating at Copper Mountain, British Columbia is converting its diesel-electric haul trucks to trolley assist for the climb out of the pit, with power being supplied by the mine's existing transmission supply from BC Hydro.

Germany

edit
 
Scania R-series trolleytruck on display at a motor show in Germany. Note:the double pantograph seen on the back of the driver's cabin

The German Federal Ministry for the Environment is building a network of overhead wires along the autobahn for diesel-electric hybrids, allowing trucks to cruise on electric power.[8][9] A short test stretch has been built on an army base in Brandenburg, with longer routes in Hesse and Schleswig-Holstein planned for 2018.[10] The test in Schleswig-Holstein started on 1 June 2019 and in Hesse on 7 May 2019. A further test is planned in Baden-Württemberg.[11]

Italy

edit

Trolleytrucks were used by the AEM electric utility company of Milan, Italy, to supply construction materials and service to the San Giacomo Dam (constructed 1940–1950) and the second Cancano Dam (constructed 1952–1956).[12][13][14] The two trolleytruck lines in the Valtellina valley that helped to build then supply the dams along the Spöl river were used from 1938 to 1962.[4]

Namibia

edit

The Rössing Uranium Mine in Namibia installed a trolley assist system around 1986.[4] The diesel electric drive Komatsu 730E dump trucks were converted at that time to use trolley power assist for the climb out of the mine to the crusher. The fleet numbered more than 10 vehicles as of 2001.[4]

South Africa

edit

Trolleytrucks were introduced to the Palabora copper mine in South Africa in 1980.[4][15]

The South African Iron and Steel Industrial Corporation (ISCOR) installed a 7.7 kilometres (4.8 mi) trolley power assist line for 170 short tons (152 long tons; 154 t) diesel electric trucks at its Shishen mine in March 1982.[4] Afterwards the company also installed a trolley power assist system at its Grootegeluk coal mine in Lephalale, South Africa. ISCOR (now known as Mittal Steel South Africa) is the largest user of trolley power assist trolleytruck systems in the world.[16]

Soviet Union, Russia, Ukraine

edit

Many cities in the Soviet Union operated trolleytrucks. The MAZ-525 truck model was converted to a trolleytruck design in 1954 in Kharkiv, Ukraine. The Kharkiv experiment with trolleytrucks was stopped because of disadvantages.

Nowadays trolleytrucks operate in several cities in Ukraine such as Donetsk and Sevastopol[17] as well as cities in Russia such as Bryansk and Saint Petersburg. One type, the KTG-1, is made for service and repair of the urban trolleybus vehicles; while another, the KTG-2, is used for transporting goods.

Sweden

edit

The first public electrified motorway opened in Sweden on 22 June 2016 on a stretch of European route E16 near Gävle, allowing hybrid and battery electric Scania lorries to run from overhead wires.[18]

Switzerland

edit

Trolleytrucks were used in Gümmenen and Mühleberg Switzerland between 1918 and 1922 during the construction of the dam that retains Lake Wohlen. The trucks were built by Tribelhorn, and they used the Stoll system of current collection.

United States

edit

Trolleytrucks have been used in mining operations and in road maintenance projects in the United States.[19]

Michigan

edit

From 1939 to 1964 the International Salt Company mine in River Rouge, Michigan, used trolleytrucks that were converted Euclid 20 short tons (18 t) models. This was an underground salt mine. Batteries were used to power the trucks when they strayed away from the overhead wires.[4] For use within a mine, the overhead wires may occasionally be relocated as excavation activity progresses. Hence the trolleytrucks used in mines do not necessarily have a travel route that is as fixed as the trolleytruck routes used in cities.

California

edit

From 1956 to 1971 the Riverside Cement Company in Bloomington, California, operated Kenworth 30-short-ton (27 t) dump trucks converted to trolleytruck use at the Crestmore Quarry near Riverside, California.[4][20] The trucks were equipped with "extension cords" for use of electric power near the shovel down in the mine. The long extension cords stored on powered reels aboard the trolleytrucks offered them increased mobility right at the load point.

In 2014 Siemens announced the imminent start of a demonstration phase for an eHighway system in the area served by the Port of Los Angeles and Port of Long Beach. The announcement stated the eHighway would be a one-mile two-way stretch of road on the north- and south-bound sections of Alameda Street near where it intersects with Sepulveda Boulevard in Carson, California. The trucks have a second power source (diesel, compressed natural gas (CNG), or battery) so they can pull out from under the wires e.g. to pass a stopped vehicle, or when not using the eHighway. They are built by Mack Trucks in cooperation with Siemens. The demonstration phase is scheduled to last for one year.[21] The initial announcement anticipated the trials would start in 2015; however, the system did not begin use until 2017[22]

New Mexico

edit

The El Chino Mine near Santa Rita, New Mexico installed trolleytrucks in 1967.[23] The trucks are equipped with diesel engines and the trolley power is used to assist the trucks up and down the ramp that leads into the mine. This type of double power arrangement is known as a trolley assist system.[24]

Nevada

edit
See also: Gold mining in Nevada

Barrick's Goldstrike mine, Nevada used trolleytrucks from 1994 to 2001 when the trolley system was decommissioned due to a large reconfiguration of the mine.[4][25] The system was similar to the one used in the Palabora copper mine in South Africa.

Zambia

edit

Trolleytrucks were used in the Zambia Consolidated Copper Mines Nchanga Mine in Zambia from 1983 until later in the 1980s.[4] Inexpensive hydroelectricity is generated at the Kariba Power Station along the Zambezi river and distributed throughout the "copper belt" of Zambia. The current delivery for the trolley power assisted diesel trucks (120 short tons (110 t)) was done through custom designed bus bars and large current collection shoes mounted on very large trolley pole-like collectors.

See also

edit

References

edit
  1. ^ In the United Kingdom a trolley may refer to the hand operated wheeled vehicle called a hand truck in North America. In North American usage the term trolley truck may also be used to refer to the wheelset or bogie that a streetcar rides upon.
  2. ^ Trams may collect current from a single wire with a single trolley pole or pantograph and return the current to earth via the rail.
  3. ^ "Siemens History – Industry & Automation". 2009-01-12.
  4. ^ a b c d e f g h i j k Dave Hutnyak. "Trolley History". Hutnyak Consulting. Retrieved 2009-01-12.
  5. ^ "Trolleytrucks". Retrieved 2009-01-10.
  6. ^ Wolfgang Auer. "St. Lambrecht Trolley-truck Line". Retrieved 2009-01-10.
  7. ^ "Pleven and its trolleybus system – The trolleybuses of Pleven, Bulgaria". Retrieved 2009-01-13.
  8. ^ "eHighway – Solutions for electrified road freight transport". press.siemens.com. Retrieved 2024-07-03.
  9. ^ Ewing, Jack (2021-08-03). "What if Highways Were Electric? Germany Is Testing the Idea". The New York Times. ISSN 0362-4331. Archived from the original on 2021-08-03. Retrieved 2024-07-03.
  10. ^ "Elektro-Lkw mit Oberleitung rollen bald in Hessen". Hessenschau. 24 January 2017. Retrieved 24 January 2017.
  11. ^ "Das Pilotprojekt „eWayBW"". Was ist eWayBW? (in German). Retrieved 2024-07-03.
  12. ^ "A2A – Cancano Dam". Archived from the original on February 11, 2009. Retrieved 2009-01-12.
  13. ^ "A2A – San Giacomo Dam". Archived from the original on February 11, 2009. Retrieved 2009-01-12.
  14. ^ "A2A – AEM". Archived from the original on February 11, 2009. Retrieved 2009-01-12.
  15. ^ "Palabora Mining Company". Retrieved 2009-01-13.
  16. ^ "ISCOR Mining, South Africa – 1982 to 2001". Retrieved 2009-01-13.
  17. ^ "Sevastapol-TG104.JPG". Retrieved 2009-01-10.
  18. ^ "World's first electric road opens in Sweden". Scania. 22 June 2016. Retrieved 24 January 2017.
  19. ^ "Kenworth Trolleytruck in Seattle, Washington; May 1956". Retrieved 2009-01-04.
  20. ^ The Riverside Cement Company was sold to the SsangYong Group which then sold Riverside Cement to Texas Industries.
  21. ^ Postnikov, Vladimir (August 7, 2014). "California gets eHighway".
  22. ^ Ridden, Paul (November 10, 2017). "Trucks start rolling down California eHighway".
  23. ^ Dave Hutnyak's "Trolley History" page mentions that Kennecott Utah Copper operated the "Chino" mine in New Mexico in the 1960s. Note that the mine is now owned by Freeport-McMoRan.
  24. ^ "Trolley Overview". Retrieved 2009-01-13.
  25. ^ "Barrick Gold Corporation – Global Operations – North America – Goldstrike Property". Archived from the original on 2009-02-02. Retrieved 2009-01-13.
edit
 
Wikimedia Commons has media related to Trolley trucks.
Retrieved from "https://en.wikipedia.org/w/index.php?title=Trolleytruck&oldid=1241754234"